Investigation of the Interaction of Surfactant at Variable Salinity with Permian Basin Rock Samples: Completion Enhancement and Application for Enhanced Oil Recovery
- Kang Han Park (Texas A&M University) | David S. Schechter (Texas A&M University)
- Document ID
- Society of Petroleum Engineers
- SPE Drilling & Completion
- Publication Date
- March 2020
- Document Type
- Journal Paper
- 100 - 113
- 2020.Society of Petroleum Engineers
- imbibition, unconventional, salinity, wettability, surfactant
- 4 in the last 30 days
- 110 since 2007
- Show more detail
- View rights & permissions
|SPE Member Price:||USD 5.00|
|SPE Non-Member Price:||USD 35.00|
Adding a surfactant to completion fluids has been widely applied to improve the initial oil production from unconventional liquid reservoirs (ULRs). However, very limited research has been conducted to understand the interactions between surfactants and salt in ULRs, and to identify the effect of zeta-potential (ZP), interfacial tension (IFT), and contact angle (CA) on oil recovery through surfactant/salt-assisted spontaneous imbibition (SSASI). This study investigates the interactions of surfactant and salinity in different ULR lithologies in west Texas (WT), USA, and determines the relationship between the experimental parameters and oil recovery to provide potential screening criteria for completion-fluid design.
With the combination of numerous chemicals at different concentrations and nine salinity levels, more than 50 variations of aqueous-phase solution were blended. Also, heterogeneous ULR rock samples of the WT formation with two different dominant lithologies, quartz-rich (WT QR) and carbonate-rich (WT CR), were selected. All combinations of fluid were used for ZP, IFT, and CA measurements, and some were selected for SSASI experiments with timely computed-tomography (CT) scans. Then, all experimental results were plotted against the oil recovery factor (RF) to determine the most impactful parameter on oil recovery and to obtain knowledge regarding desired conditions of salinity for surfactant-added completion fluid.
The effect of salinity on ZP, IFT, and CA had a similar trend for all fluid cases. With increasing salinity, the magnitude of ZP decreased to nearly 0 mV, meaning either a thin electrical double layer (EDL) or none surrounding the rock particles. Surfactant and salt reduced IFT strongly until it reached the critical salt concentration (CSC) of 30,000 ppm, and then reduction occurred gradually and slowly. Surface wettability was different for the two rock types, and the ability to alter wettability varied by the condition of fluids. Wettability alteration occurred with the presence of both surfactant and salt, but most effectively at salinity between 20,000 and 30,000 ppm. Also, the wettability of the quartz-rich rock type showed more water-wetting surface compared with the carbonate-rich rock type. Out of all the experimental parameters, CA showed the strongest effect on oil recovery. Only 5 to 10% of the oil was produced when the rock surface was oil-wet, but the oil recovery increased up to 25% when the surface became intermediate-wet. Finally, when the rock surface became water-wet, 25 to 40% of the oil was produced from SSASI. Consequently, on the basis of this investigation of surfactant/salt interactions, we determined the salinity of 20,000 to 33,000 ppm to be the most favorable condition for salt/surfactant-added completion fluids, which effectively reduces IFT and yields the strongest wettability alteration.
Understanding the interactions between salt and surfactant and their behaviors in different types of reservoirs is essential when analyzing the reusability or dilution of high-salinity produced water and successfully designing completion fluids for ULRs. The significance of this study is the ability to determine the most synergetic condition of blended-salt/surfactant solutions and identify the parameter with the greatest impact on oil recovery in ULRs to provide surfactant-screening criteria. Furthermore, we demonstrate economic and environmental benefits by using produced water and fresh water for completion activities.
|File Size||1 MB||Number of Pages||14|
Alvarez, J. O. and Schechter, D. S. 2016a. Altering Wettability in Bakken Shale by Surfactant Additives and Potential of Improving Oil Recovery During Injection of Completion Fluids. Paper presented at the SPE Improved Oil Recovery Conference, Tulsa, Oklahoma, USA, 11–13 April. SPE-179688-MS. https://doi.org/10.2118/179688-MS.
Alvarez, J. O. and Schechter, D. S. 2016b. Wettability, Oil and Rock Characterization of the Most Important Unconventional Liquid Reservoirs in the United States and the Impact on Oil Recovery. Paper presented at the SPE/AAPG/SEG Unconventional Resources Technology Conference, San Antonio, Texas, USA, 1–3 August. URTEC-2461651-MS. https://doi.org/10.15530/URTEC-2016-2461651.
Alvarez, J. O. and Schechter, D. S. 2017. Wettability Alteration and Spontaneous Imbibition in Unconventional Liquid Reservoirs by Surfactant Additives. SPE Res Eval & Eng 20 (1): 107–117. SPE-177057-PA. https://doi.org/10.2118/177057-PA.
Alvarez, J. O., Neog, A., Jais, A. et al. 2014. Impact of Surfactants for Wettability Alteration in Stimulation Fluids and the Potential for Surfactant EOR in Unconventional Liquid Reservoirs. Paper presented at the SPE Unconventional Resources Conference, The Woodlands, Texas, USA, 1–3 April. SPE-169001-MS. https://doi.org/10.2118/169001-MS.
Alvarez, J. O., Saputra, I. W. R., and Schechter, D. S. 2017a. The Impact of Surfactant Imbibition and Adsorption for Improving Oil Recovery in the Wolfcamp and Eagle Ford Reservoirs. Paper presented at the SPE Annual Technical Conference and Exhibition, San Antonio, Texas, USA, 9–11 October. SPE-187176-MS. https://doi.org/10.2118/187176-MS.
Alvarez, J. O., Tovar, F. D., and Schechter, D. S. 2017b. Improving Oil Recovery in Unconventional Liquid Reservoirs by Soaking-Flowback Production Schedule with Surfactant Additives. Paper presented at the SPE Liquids-Rich Basins Conference–North America, Midland, Texas, USA, 13–14 September. SPE-187483-MS. https://doi.org/10.2118/187483-MS.
Alvarez, J. O., Saputra, I. W. R., and Schechter, D. S. 2017c. Potential of Improving Oil Recovery with Surfactant Additives to Completion Fluids for the Bakken. Energy Fuels 31 (6): 5982–5994. https://doi.org/10.1021/acs.energyfuels.7b00573.
Khanamiri, H. H., Torsæter, O., and Stensen, J. Å. 2015. Experimental Study of Low Salinity and Optimal Salinity Surfactant Injection. Paper presented at EUROPEC 2015, Madrid, Spain, 1–4 June. SPE-174367-MS. https://doi.org/10.2118/174367-MS.
Kondash, A. and Vengosh, A. 2015. Water Footprint of Hydraulic Fracturing. Environ. Sci. Technol. Lett. 2 (10): 276–280. https://doi.org/10.1021/acs.estlett.5b00211.
Kumar, S. and Mandal, A. 2016. Studies on Interfacial Behavior and Wettability Change Phenomena by Ionic and Nonionic Surfactants in Presence of Alkalis and Salt for Enhanced Oil Recovery. Appl Surf Sci 372 (30 May): 42–51. https://doi.org/10.1016/j.apsusc.2016.03.024.
Li, X., Teklu, T. W., Abass, H. et al. 2016. The Impact of Water Salinity/Surfactant on Spontaneous Imbibition Through Capillarity and Osmosis for Unconventional IOR. Paper presented at the SPE/AAPG/SEG Unconventional Resources Technology Conference, San Antonio, Texas, USA, 1–3 August. URTEC-2461736-MS. https://doi.org/10.15530/URTEC-2016-2461736.
Mohamed, F., Al Hinai, M., Al Nabhani, H. et al. 2015. Wettability Alteration in Hydraulically Fractured Tight Sand for Flow-Back Improvement. Paper presented at the Abu Dhabi International Petroleum Exhibition and Conference, Abu Dhabi, UAE, 9–12 November. SPE-177893-MS. https://doi.org/10.2118/177893-MS.
Moniz, E. J., Jacoby, H. D., Meggs, A. J. M. et al. 2011. The Future of Natural Gas: An Interdisciplinary MIT Study. Cambridge, Massachusetts, USA: Massachusetts Institute of Technology.
Morrow, N. R. and Mason, G. 2001. Recovery of Oil by Spontaneous Imbibition. Curr. Opin. Colloid Interface Sci. 6 (4): 321–337. https://doi.org/10.1016/S1359-0294(01)00100-5.
Neog, A. and Schechter, D. S. 2016. Investigation of Surfactant Induced Wettability Alteration in Wolfcamp Shale for Hydraulic Fracturing and EOR Applications. Paper presented at the SPE Improved Oil Recovery Conference, Tulsa, Oklahoma, USA, 11–13 April. SPE-179600-MS. https://doi.org/10.2118/179600-MS.
Pankaj, P. and Kumar, V. 2010. Well Testing in Tight Gas Reservoir: Today. Paper presented at the SPE Oil and Gas India Conference and Exhibition, Mumbai, India, 20–22 January. SPE-129032-MS. https://doi.org/10.2118/129032-MS.
Saputra, I.W. R. and Schechter, D. S. 2018. Comprehensive Workflow for Laboratory to Field-Scale Numerical Simulation to Improve Oil Recovery in the Eagle Ford Shale by Selective Testing and Modelling of Surfactants for Wettability Alteration. Paper presented at the SPE/AAPG/SEG Unconventional Resources Technology Conference, Houston, Texas, USA, 23–25 July. URTEC-2884598-MS. https://doi.org/10.15530/URTEC-2018-2884598.
Saxena, N., Kumar, A., and Mandal, A. 2019. Adsorption Analysis of Natural Anionic Surfactant for Enhanced Oil Recovery: The Role of Mineralogy, Salinity, Alkalinity and Nanoparticles. J Pet Sci Eng 173 (February): 1264–1283. https://doi.org/10.1016/j.petrol.2018.11.002.
US Energy and Information Administration (EIA). 2017. Annual Energy Outlook 2017 with Projections to 2050. Report No. AEO2017, US EIA, Washington, DC (5 January 2017).
Valluri, M. K., Alvarez, J. O., and Schechter, D. S. 2016. Study of the Rock/Fluid Interactions of Sodium and Calcium Brines with Ultra-Tight Rock Surfaces and Their Impact on Improving Oil Recovery by Spontaneous Imbibition. Paper presented at the SPE Low Perm Symposium, Denver, Colorado, USA, 5–6 May. SPE-180274-MS. https://doi.org/10.2118/180274-MS.
Whitfield, S. 2017. Permian, Bakken Operators Face Produced Water Challenges. J Pet Technol 69 (6): 48–51. SPE-0617-0048-JPT. https://doi.org/10.2118/0617-0048-JPT.
Wilson, A. 2016. Produced-Water Reinjection—Case Study from Onshore Abu Dhabi. J Pet Technol 68 (12): 72–73. SPE-1216-0072-JPT. https://doi.org/10.2118/1216-0072-JPT.
Zhang, F., Adel, I. A., Park, K. H. et al. 2018a. Enhanced Oil Recovery in Unconventional Liquid Reservoir Using a Combination of CO2 Huff-N-Puff and Surfactant-Assisted Spontaneous Imbibition. Paper presented at the SPE Annual Technical Conference and Exhibition, Dallas, Texas, USA, 24–26 September. SPE-191502-MS. https://doi.org/10.2118/191502-MS.
Zhang, F., Saputra, I. W. R., Adel, I. A. et al. 2018b. Scaling for Wettability Alteration Induced by the Addition of Surfactants in Completion Fluids: Surfactant Selection for Optimum Performance. Paper presented at the SPE/AAPG/SEG Unconventional Resources Technology Conference, Houston, Texas, USA, 23–25 July. URTEC-2889308-MS. https://doi.org/10.15530/URTEC-2018-2889308.
Zhang, F., Saputra, I. W. R., Niu, G. et al. 2018c. Upscaling Laboratory Result of Surfactant-Assisted Spontaneous Imbibition to the Field Scale through Scaling Group Analysis, Numerical Simulation, and Discrete Fracture Network Model. Paper presented at the SPE Improved Oil Recovery Conference, Tulsa, Oklahoma, USA, 14–18 April. SPE-190155-MS. https://doi.org/10.2118/190155-MS.