Productivity Loss in Gas Wells Caused by Salt Deposition
- Duc Le (University of Tulsa) | Jagannathan Mahadevan (University of Tulsa)
- Document ID
- Society of Petroleum Engineers
- SPE Journal
- Publication Date
- December 2011
- Document Type
- Journal Paper
- 908 - 920
- 2011. Society of Petroleum Engineers
- 3 Production and Well Operations
- capillary wicking, formation damage, salt deposition
- 5 in the last 30 days
- 650 since 2007
- Show more detail
- View rights & permissions
|SPE Member Price:||USD 12.00|
|SPE Non-Member Price:||USD 35.00|
Production of gas can result in drying of the near-wellbore region caused by gas expansion, which causes evaporation and hence salt deposition. The deposition of salt leads to a reduction in porosity and permeability of the rock in the near-wellbore region, which then leads to reduction in well productivity. The main objective of this work is to understand the role of capillarity on salt deposition and its impact on well flow efficiency.
We develop and solve the dimensionless-conservation equations for solid-salt saturation using numerical methods under radial-flow conditions. The results of the calculations show that when the capillary effects are strong, the salt accumulates near the wellbore, which leads to plugging and hence higher skin values. The salt saturation continues to evolve until a limiting value, in the rock pores, is reached. Higher values of the limiting saturation lead to a greater reduction in permeability and therefore result in a larger skin value for the gas well. The flow efficiency of a gas well, calculated as a dimensionless ratio of the flow with and without skin, decreases continually and asymptotically approaches a constant value.
In a simulation for a typical field case, we find that the largest increase in skin factor and corresponding decrease in flow efficiency occur in approximately the first 30 days, after which the changes are slower. When connate-water salt concentration is higher, the skin value is much higher and thus the well productivity is lower. Using the model developed in this study, the decline of gas-well productivity caused by salt deposition can be predicted and hence accurate timing of well operations, such as water wash, can be made. Also, the modeling study can be used to select remediation strategies such as wettability alteration to reduce capillarity or application of inhibitors, which can reduce the limiting salt saturation by preventing growth of salt crystals within the reservoir rock.
|File Size||1 MB||Number of Pages||13|
Jasinski, R., Sablerolle, W. , and Amory, M. 1997. ETAP: ScalePrediction and Contol for the Heron Cluster. Paper SPE 38767 presented at theSPE Annual Technical Conference and Exhibition, San Antonio, Texas, USA, 5-8October. doi:10.2118/38767-MS.
Kirk, J.W. and Dobbs, J.B. 2002. A Protocol to Inhibit the Formation ofNatrium Chloride Salt Blocks. Paper SPE 74662 presented at the InternationalSymposium on Oilfield Scale, Aberdeen, 30-31 January. doi: 10.2118/74662-MS.
Kleinitz, W., Kehler, M. , and Dietzsch, G. 2001. The Precipitation ofSalt in Gas Producing Wells. Paper SPE 68953 presented at the SPE EuropeanFormation Damage Conference, The Hague, The Netherlands, 21-22 May. doi: 10.2118/68953-MS.
Le, D., Hoang, H., and Mahadevan, J. 2009. Impact of Capillary-Driven LiquidFilms on Salt Crystallization. Transport in Porous Media 80(2): 229-252. doi:10.1007/s11242-009-9353-x.
Mahadevan, J., Sharma, M.M. , and Yortsos, Y.C. 2007. CapillaryWicking in Gas Wells. SPE J. 12 (4): 429-437.SPE-103229-PA. doi:10.2118/103229-PA.
Page, A.J. and Sear, R.P. 2006. Heterogeneous Nucleation in and out ofPores. Phys. Rev. Lett. 97 (6): 065701. doi:10.1103/PhysRevLett.97.065701.
Place, M.C. Jr. and Smith, J.T. 1984. An Unusual Case of Salt Plugging in aHigh-Pressure Sour Gas Well. Paper SPE 13246 presented at the SPE AnnualTechnical Conference and Exhibition, Houston, 16-19 September. doi: 10.2118/13246-MS.
Ransohoff, T.C. and Radke, C.J. 1988. Laminar Flow of a Wetting Liquid Alongthe Corners of a Predominantly Gas-Occupied Non-Circular Pore. Journalof Colloid and Interface Science 121 (2): 392.
Van Dorp, Q.T., Slijkhuis, M. and Zitha, P.L.J. 2009. Salt Precipitation inGas Reservoirs. Paper SPE 122140 prepared for presentation at the 8th EuropeanDamage Conference, Scheveningen, The Netherlands, 27-29 May. doi: 10.2118/122140-MS.
Zuluaga, E. and Lake, L.W. 2008. Modeling of Experiments on WaterVaporization for Gas Injection Using Traveling Waves. SPE J. 13 (2): 248-256. SPE-91393-PA. doi: 10.2118/91393-PA.
Zuluaga, E. and Monsalve, J.C. 2003. Water Vaporization in Gas Reservoirs.Paper SPE 84829 presented at the SPE Eastern Regional Meeting, Pittsburgh,Pennsylvania, USA, 6-10 September. doi: 10.2118/84829-MS.